LOADER CHECK LIST

                                                                                                                                                                                                                                      • • • • NEW OR RECENTLY REPLACED

                        63X4715                                                                                                                                                                        • • • PERFORMS WITHIN TOLERANCES

                                                                                                                                                                                                                                      • • PERFORMS BUT SHOWS SIGNS OF NEEDING REPAIR OR REPLACEMENT

                                                                                                                                                                                                                                      • NEEDS REPAIR OR REPLACEMENT IN ORDER TO PERFORM PROPERLY

 

GENERAL APPEARANCE

ITEM

ASSESSMENT
SHEET METAL / FIBERGLASS CONDITION • • •
PAINT •
PICTURE – FRONT
PICTURE – LEFT SIDE
PICTURE – RIGHT SIDE
PICTURE – REAR
PICTURE – GROUP

OPERATOR STATION

ITEM

ASSESSMENT
STEPS / LADDER • • MISSING REAR LEFT STEP, LH OPERATOR STEP BENT
HAND RAILS • • •
MIRRORS • • •
GLASS • • •
EXTERNAL LIGHTS OPERATIONAL • • EXCEPT TWO ON ROPS
SEAT / ARMRESTS • • •
SEAT BELT •
HORN • • •
CONTROL LOCK LEVER • • •
HYDRAULIC CONTROLS LOCKED OUT
STEERING CONTROLS • • •
POWERTRAIN CONTROLS 4TH GEAR BLOCKED OUT FWD & REV.
OIL PRESSURE 56 PSI COLD AT IDLE
ENGINE WARNING LIGHTS OPERATIONAL LOW FUEL LIGHT STAYS ON
BACK UP ALARM OPERATIONAL •
GAUGES OPERATIONAL • • •
AIR CONDITIONER OPERATIONAL NO AIR CONDITIONER
HEATER OPERATIONAL • • •
HOUR METER OPERATIONAL • • •
LIMITED FUNCTION CHECK The components that were checked performed properly with exceptions noted.

ENGINE

ITEM

ASSESSMENT
HOUR METER READING 7028.0

McDowell Group makes no guarantee as to actual hours and or miles, reported reading is what we observed.
MAKE / MODEL Cat 3406A
SERIAL NUMBER NO TAG

ENGINE CONTINUED

ITEM

ASSESSMENT
STARTER • • •
BATTERY • • •
TURBO CHARGER • • •
EXHAUST SYSTEM CONDITION • • •
INJECTOR PUMP • • •
RADIATOR • • • -35 DEGREES CESIUS
COOLING SYSTEM LEAKS NONE VISIBLE
OIL LEAKS SMALL LEAK ON OIL PAN GASKET
CYLINDER HEAD GASKET LEAKS NONE VISIBLE
FUEL LINE AND INJECTOR LEAKS NONE VISIBLE
EMISSIONS CONTROL LABEL NOT PRESENT
BLOW BY – CHECKED AT IDLE • • •
LIMITED FUNCTION CHECK THE ENGINE PERFORMS WELL

POWERTRAIN

ITEM

ASSESSMENT
TRANSMISSION TYPE POWER SHIFT
TRANSMISSION SERIAL AND AR# NO TAG
TORQUE CONVERTER • • •
DIFFERENTIAL FRONT • • •
DIFFERENTIAL REAR • • •
QUICK COUPLER IF PRESENT NO COUPLER BUT HAS 3RD VALVE
FINAL DRIVES • • •
LIMITED FUNCTION CHECK POWERTRAIN OPERATED VERY WELL

CHASSIS VISUAL CHECK

ITEM

ASSESSMENT
BUCKET & CUTTING EDGE/TEETH NO BUCKET
LIFT ARM CONDITION NO BOOM
STEERING LINKAGE • • •
ARTICULATION JOINT • • •
UPPER LIFT ARM PINS & BUSHINGS NO BOOM
TILT LINKAGE PINS & BUSHINGS NO BOOM
BUCKET PINS & BUSHINGS NO BUCKET
STEERING WHEEL PLAY • • •
BRAKES SERVICE WILL NOT HOLD IN 2ND GEAR
BRAKES PARK WILL NOT HOLD IN 2ND GEAR
MASTER CYLINDER 1 MASTER CYL. LOW OIL
BRAKE LINES • • •
TIRES, SIZE, MAKE, WEAR 29.5R25 GOODYEAR, STUDDED

HYDRAULICS

ITEM

ASSESSMENT
PUMPS NOT TESTED
VALVES NOT TESTED
HOSES • • •
CYLINDERS • • •
CYLINDER PINS AND BUSHINGS
LIMITED FUNCTION CHECK COULD NOT TEST UNDER LOAD

 

NOTES:

• IN GENERAL HOSING LOOKS GOOD, THERE ARE A COUPLE OF HOSES THAT SHOULD BE CHECKED

• COULD NOT GIVE ASSESMENT OF HYDRAULICS WITHOUT BOOM OR BUCKET, STEERING OPERATES VERY WELL

• FRONT FRAME IS IN POOR CONDITION

• REAR FRAME HAS BEEN WELDED ABOVE AXLE ON BOTH SIDES

 

 

 

LEGEND

• • • • NEW OR RECENTLY REPLACED

• • • PERFORMS WITHIN TOLERENCES

• • PERFORMS BUT SHOWS SIGNS OF NEEDING REPAIR OR REPLACEMENT

• NEEDS REPAIR OR REPLACEMENT IN ORDER TO PERFORM PROPERLY