ITEM
ASSESSMENT
STK# 5012 TRUCK CHECK LIST
DATE_FEB__________________________________GENERAL APPEARANCE
|
ITEM |
ASSESSMENT |
| SHEET METAL / FIBERGLASS CONDITION | There are some small dents |
| PAINT | • • • |
| PICTURE – FRONT |
|
| PICTURE – LEFT SIDE |
|
| PICTURE – RIGHT SIDE |
|
| PICTURE – REAR |
|
| GROUP PICTURE |
|
OPERATOR STATION
|
ITEM |
ASSESSMENT |
| STEPS / LADDER | • • • |
| HAND RAILS | • • • |
| MIRRORS | • • • |
| GLASS | • • • Missing one slider on driver door |
| SEAT / ARMRESTS | • • • no arm rests |
| SEAT BELT | • • • |
| HORN | |
| HYDRAULIC CONTROLS | |
| STEERING CONTROLS | • • • |
| POWERTRAIN CONTROLS | • • • |
| OIL PRESSURE | |
| ENGINE WARNING LIGHTS OPERATIONAL | |
| EXTERIOR LIGHTS OPERATIONAL | |
| BACK UP ALARM OPERATIONAL | |
| GAUGES OPERATIONAL | |
| HOUR METER OPERATIONAL | |
| HEATER OPERATIONAL | |
| LIMITED FUNCTION CHECK | The components that were checked performed properly with exceptions noted. |
ENGINE
|
ITEM |
ASSESSMENT |
| HOUR METER READING 19067 | McDowell Group makes no guarantee as to actual hours and or miles, reported reading is what we observed. |
| MAKE / MODEL | Cat 3406 |
| SERIAL NUMBER | |
| EMISSIONS CONTROL LABEL | none present |
| BLOW BY – CHECKED AT IDLE | |
| STARTER | • • • |
| BATTERY | • • Weak |
| TURBO CHARGER | • • • |
| EXHAUST SYSTEM CONDITION | • • • Missing rain cap |
| INJECTOR PUMP | |
| RADIATOR | Drained, coolant was weak |
| OIL LEAKS | |
| CYLINDER HEAD GASKET LEAKS | |
| FUEL LINE AND INJECTOR LEAKS | |
| LIMITED FUNCTION CHECK | Truck ran when it came in, disabled for winter. |
POWERTRAIN
|
ITEM |
ASSESSMENT |
| TRANSMISSION | |
| TORQUE CONVERTER | |
| FINAL DRIVES | |
| DRIVESHAFTS | DISCONNECTED AT ARTICULATION JOINT |
| LIMITED FUNCTION CHECK |
CHASSIS VISUAL CHECK
|
ITEM |
ASSESSMENT |
| DUMP BED CONDITION | • • • |
| BED PIVOT PINS CONDITION | |
| BED SUPPORT PAD CONDITION | |
| SUSPENSION CYLINDERS | |
| SPRINGS & HANGERS | |
| SUSPENSION TRUNIONS | |
| BELLY PAN(S) | All attached |
| ARTICULATION CENTRE PINS | Recently reconditioned |
| STEERING LINKAGE | |
| STEERING WHEEL PLAY | |
| BRAKES | Air, holding at 60 psi |
| MASTER CYLINDER | |
| BRAKE CONTROL VALVE | |
| BRAKE LINES/HOSES | |
| PARK BRAKE | |
| TIRE SIZE | 29.5 x 25 |
| TIRE CONDITION | 30% - 40% good |
| WHEEL CONDITION | Flanges have some dents, slight bend. |
| LIMITED FUNCTION CHECK | WEAR AS NOTED |
HYDRAULICS
|
ITEM |
ASSESSMENT |
| PUMPS | |
| VALVES | |
| HOSES | |
| CYLINDERS | |
| CYLINDER PINS AND BUSHINGS | |
| LIMITED FUNCTION CHECK |
NOTES:
Skid plates are still on unit, could not inspect bottom of the engine
Dump box has had repair welding done
Engine and Transmission compartment shows signs of normal leakage, when unit was running no major oil leaks were noted
• • • • NEW OR RECENTLY REPLACED
• • • PERFORMS WITHIN TOLERENCES
• • PERFORMS BUT SHOWS SIGNS OF NEEDING REPAIR OR REPLACEMENT
• NEEDS REPAIR OR REPLACEMENT IN ORDER TO PERFORM PROPERLY